Pdf download ezgo

S6 Electric Express S4 Electric Express S4 Gas Express S4 High Output Electric RXV Electric RXV Elite RXV Gas TXT Electric TXT Elite TXT Gas Search for:.

Previous Next. Always maintain adequate distance between vehicles. Because hydrogen gas is lighter than air, it will collect in the ceiling of buildings necessitating proper ventilation. Notes: Page viii Repair and Service Manual Thank you for purchasing this vehicle. This repair manu- Serial Number al contains information that will assist you in repairing and maintaining this vehicle.

Do not ride on a vehicle being towed. Tow bars are designed to tow only one vehicle at a maximum speed of 12 mph 19 kph and up to three vehicles at a maximum speed of 5 mph 8 kph. This vehicle will give years of satisfactory service pro- The painted surfaces of the vehicle provide attractive viding it receives regular maintenance.

Grade 5 hardware can be identified by the three marks on the hexagonal head and grade 8 hardware is identi- Maximum speed with sun top installed is 50 fied by 6 marks on the head. B - 1 Additional Warnings Accessories connected to this vehicle that do not use amount required by the accessory. Battery Strap Floor Jack To raise only the front or rear of the vehicle, place the wheel chocks in front and behind the rear wheels. The jack may be left under the center front of the frame while the front end of the vehicle is on the jack stands.

C - 1 General C - 2 Front Bumper C - 2 Rocker Panels C - 2 Floor Mat C - 2 Cowl and Instrument Panel Torx bit, TIP Using an insulated wrench, disconnect the bat- tery cable at the negative - , BL-, battery ter- minal.

If the vehicle is equipped with a sun top and windshield; remove these items before proceeding. Remove three self threading nuts 20 securing the Front Splash Guard Ref. Installation is in the reverse order of removal. Loosen the torx head bolts 23 and nuts 22 Ref. Sandpaper, Grit wet or dry D - 1 Tire Repair D - 1 Wheel Installation E - 1 Accelerator Pedal Assembly E - 2 Solenoid Replacement E - 3 Controller Remove pedal cover. Tool List Qty. Solenoid Replacement Ref Fig. Drain the stored energy from the controller.

F - 1 Tire Wear Diagnosis F - 2 Wheel Alignment F - 2 Hub Assembly F - 3 Spindle Assembly F - 3 Struts Wear on either side of a correctly inflated the wheels in line with the body of the vehicle it will tire indicates a tire that is out of alignment. To adjust the wheel alignment, loosen the tie rod jam mended that locking nuts be replaced after a maxi- nut 1 and turn the tie rods and equal number of turns mum of 5 removals until the correct alignment is achieved.

Struts Ref Fig. Wrench, 15mm It comes with enhanced firmness over the entire length of the shaft Skip to content Table of Contents. Continue Reading Continue Reading. Welded steel featuring DuraShield epoxy coating. Ground clearance at differential. Dash-mounted, forward-neutral-reverse. Two people Equipped with the provision for adding an extra rear-facing seat.

Three EZGO golf carts using a permanent and approved tow bar.